[Rhodes22-list] Mast Step Popped

[Hank]

Rick,

Did you epoxy the mast plate to the deck?  If so, that was your problem.
 The epoxy is only used to fill the hole.  The mast plate should only be
attached to the deck by the screws and not any type of adhesive.

Hank

On Tue, Sep 13, 2011 at 9:40 AM, Rick <sloopblueheron at gmail.com> wrote:

> Rummy,
>
> I did this repair using epoxy.  The subsequent tear-off of the plate caused
> extensive damage, including a crack that ran all the way to a cabin rail.
>
> Are you sure Stan uses epoxy?  I suspect he uses something with shear
> strength more approaching wood.  Plus, the underlying wood can't have rot
> and there can't be any voids between the wood and gelcoat.
>
> Rick
>
> On Tue, Sep 13, 2011 at 9:00 AM, <R22RumRunner at aol.com> wrote:
>
> > Rick,
> > I'm not sure where you are going with this. The repair that has been
> >  mentio
> > ned has been done by many Rhodies over the years. It is the best way to
> > repair the step. It is the repair that Stan uses at the factory.
> >
> > Rummy
> >
> >
> > In a message dated 9/12/2011 11:08:29 P.M. Eastern Daylight Time,
> > sloopblueheron at gmail.com writes:
> >
> > David,
> >
> > Your problem won't be the epoxy holding with careful  raising and lower
> of
> > your mast.  Your problem will be the damage done  by the epoxy when you
> > have
> > another mishap.
> >
> > Rick
> >
> > On Mon, Sep  12, 2011 at 9:08 PM, David Craft <Chsyhkr at gmail.com>
>  wrote:
> >
> > >
> > > Rob,
> > >
> > > I was raising the mast from  the back using the crutch that hangs off
> the
> > > transom.
> > >
> > >  As we started to raise the mast, we realized we need to manuever the
> >  jib
> > > around a shroud.   He set the mast down on back rail and  not back in
> the
> > > crutch.  It was enough leverage, with the pop top  acting as a fulcrum
> to
> > > pop
> > > the plate off.
> > >
> > > I  drilled out the holes today.  The wood is damp but not
>  deteriorating.
> >  I
> > > think it treated Southern Yellow Pine.  It  will be dry for a week
> here,
> > > enough time for it dry well before  repairing.  The glass is intact,
> > except
> > > for one spot around the  fore screw.  A quarter size piece, about half
> > the
> > > thickness  popped out.
> > >
> > > I think the epoxy repair should last for a good  while with careful
> > raising
> > > and lowering......
> > >
> > > David  Craft
> > >
> > >
> > >
> > > Rob Lowe wrote:
> > > >
> > >  > David,
> > > > Was this when you were raising or lowering the  mast?  Which
> direction
> > to
> > > > you lower to?  - rob
> > >  >
> > > > -----Original Message-----
> > > > From:  rhodes22-list-bounces at rhodes22.org
> > > >  [mailto:rhodes22-list-bounces at rhodes22.org] On Behalf Of David
> Craft
> > >  > Sent: Sunday, September 11, 2011 5:45 PM
> > > > To: Rhodes  List
> > > > Subject: [Rhodes22-list] Mast Step Popped
> > >  >
> > > > While setting our mast at a local lake the mast step popped  off with
> > the
> > > > screws somewhat stripped.  We reset it and  raised it carefully
> > figuring
> > > > that
> > > > the weight would  help hold it.
> > > >
> > > > While taking it down, it popped again,  necessitating the repair I
> > > expected
> > > > when it popped the  first time.
> > > >
> > > > The boat is a 89, recycled in  08.
> > > >
> > > > The step is secured with three 1 inch  screws.   I am thinking of
> > drilling
> > > > out the holes,  repairing with epoxy,  drilling new pilot holes, and
> > > >  resetting.   I have heard suggestions from inserting lugs to
>  drilling
> > all
> > > > the way through and using bolts and nuts.  The  wall for the head is
> a
> > > > support below the step, so drilling  through is not advisable.  Can
> > longer
> > > > screws be  used?
> > > >
> > > > Advice is appreciated as I need to make this  repair in the next two
> > > weeks.
> > > >
> > > > --
> > >  > Regards,
> > > >
> > > > David B. Craft
> > > >  Greensboro, NC
> > > >  __________________________________________________
> > > > To  subscribe/unsubscribe go to
> > > >  http://www.rhodes22.org/mailman/listinfo/rhodes22-list
> > > >
> > >  > For the list Charter and help with using the mailing list and
> archives
> >  go
> > > > to http://www.rhodes22.org/list
> > > >  __________________________________________________
> > > >
> > > >  __________________________________________________
> > > > To  subscribe/unsubscribe go to
> > > >  http://www.rhodes22.org/mailman/listinfo/rhodes22-list
> > > >
> > >  > For the list Charter and help with using the mailing list and
> archives
> >  go
> > > > to http://www.rhodes22.org/list
> > > >  __________________________________________________
> > > >
> > >  >
> > >
> > > --
> > > View this message in context:
> > >  http://old.nabble.com/Mast-Step-Popped-tp32444069p32452509.html
> > > Sent  from the Rhodes 22 mailing list archive at Nabble.com.
> > >
> > >  __________________________________________________
> > > To  subscribe/unsubscribe go to
> > >  http://www.rhodes22.org/mailman/listinfo/rhodes22-list
> > >
> > > For the  list Charter and help with using the mailing list and archives
> > go
> > > to  http://www.rhodes22.org/list
> > >  __________________________________________________
> > >
> > __________________________________________________
> > To  subscribe/unsubscribe go to
> > http://www.rhodes22.org/mailman/listinfo/rhodes22-list
> >
> > For the list  Charter and help with using the mailing list and archives
> go
> > to  http://www.rhodes22.org/list
> > __________________________________________________
> >
> > __________________________________________________
> > To subscribe/unsubscribe go to
> > http://www.rhodes22.org/mailman/listinfo/rhodes22-list
> >
> > For the list Charter and help with using the mailing list and archives go
> > to http://www.rhodes22.org/list
> > __________________________________________________
> >
> __________________________________________________
> To subscribe/unsubscribe go to
> http://www.rhodes22.org/mailman/listinfo/rhodes22-list
>
> For the list Charter and help with using the mailing list and archives go
> to http://www.rhodes22.org/list
> __________________________________________________
>