[Rhodes22-list] Dennis Frappier's Question
Alan Robertson
bigal_61 at msn.com
Wed Sep 21 12:34:10 EDT 2011
WE OVERCAME THE PROBLEM OF THE FURLING LINE SLIPPING UNDER THE BASEPLATE AND WINDING UP ON THE FORESTAY DRUM &TUBE IN REVERSE BY TYING A TAUT 1/8" LINE ACROSS FROM BOTTOM OF PULPIT SIDES ACROSS THE JIB FURLING LINE TO KEEP THE JIB LINE LOW ENOUGH SO IT WINDS UP PROPERLY ON THE DRUM; HOPE THAT THIS WAS WHAT YOU WERE REFERRING TO.
RIGGING, BACK STAYS, AND TRAVELER WERE SIMPLIFIED ON STAN'S OLDER BOAT DESIGNS AS THEY ARE ON OUR '83. FEWER POTENTIAL PROBLEMS.
ALAN & BARBARA ROBERTSON -THOR IV
----- Original Message -----
From: Stephen Staum<mailto:snstaum at gmail.com>
To: The Rhodes 22 Email List<mailto:rhodes22-list at rhodes22.org>
Sent: Tuesday, September 20, 2011 8:00 AM
Subject: Re: [Rhodes22-list] Dennis Frappier's Question
I agree w/ Chris on the viability of the old simple system. I lost 2
forestays (one broke under sail, the other just frayed) before learning of
the need to keep constant tension on the rigging. As long as your aft stays
are pulled tight w the tensioner, the forestay lasts for many years.
The beauty of the old system is that it never jams. As long as you don't
allow the furling line to unravel and slip under the baseplate (let it slide
through you fingers as you open the genny rather than just let it go) you
never have to go forward to mess with it. Simple is often better.
Sail more, fix less.
Stephen Staum
87 R22, Carol Lee
Needham, MA
-----Original Message-----
From: Chris Geankoplis
Sent: Tuesday, September 20, 2011 12:19 AM
To: 'The Rhodes 22 Email List'
Subject: Re: [Rhodes22-list] Dennis Frappier's Question
Slim has a good point; the usual breaking point is where it is swaged, the
result of a bend or kink when putting up the mast. This area needs to be
examined carefully. Fortunately you can just slide the tube up to examine
the fitting. I have not had a failure in 35 years except for the kinked end
30 years ago. That doesn't mean it won't happen sooner. Also I usually
replace my rigging about every 12 years, mostly before a big adventure.
When I examined the forestays I did not see any untwisting, but a poorly
installed bushing or too long securing screw at the head of the sail could
easily cause such a failure. If you have the money you can't go wrong with
a Flex Furl like Slim's. If not, a bit of common sense and caution will
make the tube method a reasonable choice under the circumstances.
Chris G
-----Original Message-----
From: rhodes22-list-bounces at rhodes22.org<mailto:rhodes22-list-bounces at rhodes22.org>
[mailto:rhodes22-list-bounces at rhodes22.org] On Behalf Of Slim Chance
Sent: Monday, September 19, 2011 12:37 PM
To: The Rhodes 22 Email List
Subject: Re: [Rhodes22-list] Dennis Frappier's Question
I believe there to be a flaw in this system. One that I discovered only
after my fore stay broke. The twisting of the tube over the stay can cause
the stay to unwind, wind and unwind over and over rendering it weakened.
Since you can't inspect the wire stay unless you take it all apart every so
often -- and none of us do that -- you'll never know 'til it's too late. I
replaced with the Flex Furl that I think is now common on most newer
models.
Slim
On Mon, Sep 19, 2011 at 7:39 AM, Dennis Frappier
<dennisf at maine.rr.com>wrote<mailto:dennisf at maine.rr.com%3Ewrote>:
> Dear Chris,
> I got the furler pictures, thanks a bundle. Are there pieces of HDPE
under
> the disc that keeps it a few inches off the deck and out of the attachment
> at the bow?
>
> Sincerely,
>
> Dennis Frappier
> Marketing / Business Development Consultant
>
> 207-228-5388 (direct)
> www.nikken.com/apt<http://www.nikken.com/apt>
>
> Opportunity in the Healthcare Industry! Join us in the essential
evolution
> from medical intervention to self-care and lifestyle enhancement.
> www.PartnershipOffering.com<http://www.partnershipoffering.com/> (Review the 5 minute video).
>
>
> -----Original Message-----
> From: rhodes22-list-bounces at rhodes22.org<mailto:rhodes22-list-bounces at rhodes22.org>
> [mailto:rhodes22-list-bounces at rhodes22.org] On Behalf Of Chris Geankoplis
> Sent: Monday, September 19, 2011 12:28 AM
> To: 'The Rhodes 22 Email List'
> Subject: Re: [Rhodes22-list] Dennis Frappier's Question
>
> D'OH! Thanks Hank,
> Let me try this again. It is an illustrated document maybe it got
> scrubbed.
> Just to be safe I'll attach just the pictures also.
>
> -----Original Message-----
> From: rhodes22-list-bounces at rhodes22.org<mailto:rhodes22-list-bounces at rhodes22.org>
> [mailto:rhodes22-list-bounces at rhodes22.org] On Behalf Of Hank
> Sent: Sunday, September 18, 2011 8:33 PM
> To: The Rhodes 22 Email List
> Subject: Re: [Rhodes22-list] Dennis Frappier's Question
>
> Chris,
>
> Doesn't look like the pics attached.
>
> Hank
> On Sep 18, 2011 11:06 PM, "Chris Geankoplis" <napoli68 at charter.net<mailto:napoli68 at charter.net>> wrote:
> > Dennis,
> >
> > Attached are some picts of the old Aluminum tube furling jib
> > arrangement. It is a simple piece of equipment with one moving part. The
> > bushings at the bottom and top are easy to fabricate out of HDPE or
> similar
> > type of plastic. Sometimes the disk may need a bit of welding to
reattach
> > it to the tube if bad things happen to it. Hope this helps.
> >
> >
> >
> > Chris G
> >
> > __________________________________________________
> > To subscribe/unsubscribe go to
> http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
> >
> > For the list Charter and help with using the mailing list and archives
go
> to http://www.rhodes22.org/list<http://www.rhodes22.org/list>
> > __________________________________________________
> __________________________________________________
> To subscribe/unsubscribe go to
> http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
>
> For the list Charter and help with using the mailing list and archives go
> to
> http://www.rhodes22.org/list<http://www.rhodes22.org/list>
> __________________________________________________
> -------------- next part --------------
> A non-text attachment was scrubbed...
> Name: R22 Improvements 019.jpg
> Type: image/jpeg
> Size: 1935790 bytes
> Desc: not available
> Url :
>
>
http://www.rhodes22.org/pipermail/rhodes22-list/attachments/20110918/86692bf<http://www.rhodes22.org/pipermail/rhodes22-list/attachments/20110918/86692bf>
> e/attachment.jpg
> -------------- next part --------------
> A non-text attachment was scrubbed...
> Name: R22 Improvements 016.jpg
> Type: image/jpeg
> Size: 1894973 bytes
> Desc: not available
> Url :
>
>
http://www.rhodes22.org/pipermail/rhodes22-list/attachments/20110918/86692bf<http://www.rhodes22.org/pipermail/rhodes22-list/attachments/20110918/86692bf>
> e/attachment-0001.jpg
> __________________________________________________
> To subscribe/unsubscribe go to
> http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
>
> For the list Charter and help with using the mailing list and archives go
> to
> http://www.rhodes22.org/list<http://www.rhodes22.org/list>
> __________________________________________________
>
>
> __________________________________________________
> To subscribe/unsubscribe go to
> http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
>
> For the list Charter and help with using the mailing list and archives go
> to http://www.rhodes22.org/list<http://www.rhodes22.org/list>
> __________________________________________________
>
__________________________________________________
To subscribe/unsubscribe go to
http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
For the list Charter and help with using the mailing list and archives go to
http://www.rhodes22.org/list<http://www.rhodes22.org/list>
__________________________________________________
__________________________________________________
To subscribe/unsubscribe go to
http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
For the list Charter and help with using the mailing list and archives go to
http://www.rhodes22.org/list<http://www.rhodes22.org/list>
__________________________________________________
__________________________________________________
To subscribe/unsubscribe go to http://www.rhodes22.org/mailman/listinfo/rhodes22-list<http://www.rhodes22.org/mailman/listinfo/rhodes22-list>
For the list Charter and help with using the mailing list and archives go to http://www.rhodes22.org/list<http://www.rhodes22.org/list>
__________________________________________________
More information about the Rhodes22-list
mailing list